Sains Malaysiana 43(4)(2014): 617–621

Characterizations of Cupric Oxide Thin Films on Glass and Silicon Substrates

by Radio Frequency Magnetron Sputtering

(Pencirian Kuprik Oksida Filem Nipis atas Substrat Kaca dan Silikon

dengan Percikan Pemagnetan Frekuensi Radio)

P.K. OOI*, C.G. CHING, M.A. AHMAD, S.S. NG, M.J. ABDULLAH,

H. ABU HASSAN & Z. HASSAN

Nano-Optoelectronics Research and Technology Laboratory, School of Physics

Universiti Sains Malaysia, 11800 Penang, Malaysia

Diserahkan:  20 Februari 2013 /Diterima:  5 Ogos 2013

ABSTRACT

Cupric oxide (CuO) thin films were prepared on a glass and silicon (Si) substrates by radio frequency magnetron sputtering system. The structural, optical and electrical properties of CuO films were characterized by X-ray diffraction (XRD), atomic force microscopy (AFM), Fourier transform infrared spectrometer, ultra-violet visible spectrophotometer, respectively, four point probe techniques and Keithley 4200 semiconductor characterization system. The XRD result showed that single phase CuO thin films with monoclinic structure were obtained. AFM showed well organized nano-pillar morphology with root mean square surface roughness for CuO thin films on glass and Si substrates were 3.64 and 1.91 nm, respectively. Infrared reflectance spectra shown a single reflection peak which is corresponding to CuO optical phonon mode and it confirmed that only existence of CuO composition on both substrates. The optical direct band gap energy of the CuO film grown on glass substrate, which is calculated from the optical transmission measurement was 1.37 eV. Finally, it was found that the deposited CuO films are resistive and the palladium formed ohmic contact for CuO on glass and schottky contact for CuO on Si.

Keywords: Cupric oxide; radio frequency magnetron sputtering; ultra-violet visible spectroscopy; X-ray diffraction

ABSTRAK

Filem nipis kuprik oksida (CuO) telah disediakan pada substrat kaca dan silikon (Si) dengan sistem percikan pemagnetan frekuensi radio. Struktur sifat optik dan elektrik filem CuO dicirikan masing-masing oleh pembelauan sinar-X (XRD), mikroskopi daya atom (AFM), transformasi Fourier inframerah spektrometer, spektrofotometer ultra-ungu tampak, teknik empat titik penduga dan Keithley 4200 sistem pencirian semikonduktor. Keputusan XRD menunjukkan bahawa fasa tunggal CuO filem nipis dengan struktur monoklinik telah diperoleh. AFM menunjukkan nano tunggak morfologi terancang dengan punca min kuasa dua yang rendah kekasaran permukaan bagi CuO filem nipis atas kaca dan Si masing-masing sebanyak 3.64 dan 1.91 nm. Spektrum pantulan inframerah menunjukkan puncak refleksi tunggal yang sepadan dengan mod fonon optik CuO dan ia mengesahkan bahawa hanya komposisi CuO wujud bagi kedua-dua substrat. Jurang langsung tenaga jalur optik filem CuO, yang dikira daripada pengukuran transmisi optik, adalah 1.37 eV. Akhirnya, didapati CuO filem adalah berintangan dan Pd membentuk sentuhan ohmik bagi CuO atas kaca dan sentuhan schottky bagi CuO atas Si.

Kata kunci: Kuprik oksida; pembelauan sinar-X; percikan pemagnetan frekuensi radio; spektrofotometer ultra-ungu tampak

RUJUKAN

Balamurugan, B. & Mehta, B.R. 2001. Optical and structural properties of nanocrystalline copper oxide thin films prepared by activated reactive evaporation. Thin Solid Films 396(1- 2): 90-96.

Ching, W., Xu, Y.N. & Wong, K. 1989. Ground-state and optical properties of Cu2O and CuO crystals. Physical Review B 40(11): 7684-7695.

Dadgar, A., Schulze, F., Wienecke, M., Gadanecz, A., Bläsing, J., Veit, P., Hempel, T., Diez, A., Christen, J. & Krost, A. 2007. Epitaxy of GaN on silicon - Impact of symmetry and surface reconstruction. New Journal of Physics 9: 389.

Ilican, S., Caglar, M. & Caglar, Y. 2007. Determination of the thickness and optical constants of transparent indium-doped ZnO thin films by the envelope method. Materials Science- Poland 25(3): 709-718.

Kirk, C.T. 1988. Quantitative analysis of the effect of disorder-induced mode coupling on infrared absorption in silica. Physical Review B 38(2): 1255-1273.

Lefez, B., Souchet, R., Kartouni, K. & Lenglet, M. 1995. Infrared reflection study of CuO in thin oxide films. Thin Solid Films 268(1-2): 45-48.

Maruyama, T. 1998. Copper oxide thin films prepared by chemical vapor deposition from copper dipivaloylmethanate. Solar Energy Materials and Solar Cells 56(1): 85-92.

Motoyoshi, R., Oku, T., Kidowaki, H., Suzuki, A., Kikuchi, K., Kikuchi, S. & Jeyadevan, B. 2010. Structure and photovoltaic activity of cupric oxide-based thin film solar cells. Journal of the Ceramic Society of Japan 118(1383): 1021-1023.

Nakaoka, K., Ueyama, J. & Ogura, K. 2004. Photoelectrochemical behavior of electrodeposited CuO and Cu2O thin films on conducting substrates. Journal of the Electrochemical Society 151(10): C661-C665.

Ogale, S.B., Bilurkar, P.G., Mate, N., Kanetkar, S.M., Parikh, N. & Patnaik, B. 1992. Deposition of copper oxide thin films on different substrates by pulsed excimer laser ablation. Journal of Applied Physics 72(8): 3765-3769.

Ogwu, A.A., Bouquerel, E., Ademosu, O., Moh, S., Crossan, E. & Placido, F. 2005. The influence of rf power and oxygen flow rate during deposition on the optical transmittance of copper oxide thin films prepared by reactive magnetron sputtering. Journal of Physics D: Applied Physics 38(2): 266-271.

Oral, A.Y., Menşur, E., Aslan, M.H. & Başaran, E. 2004. The preparation of copper(II) oxide thin films and the study of their microstructures and optical properties. Materials Chemistry and Physics 83(1): 140-144.

Parretta, A., Jayaraj, M.K., Di Nocera, A., Loreti, S., Quercia, L. & Agati, A. 1996. Electrical and optical properties of copper oxide films prepared by reactive RF magnetron sputtering. Physica Status Solidi (A) 155(2): 399-404.

Pierson, J.F., Thobor-Keck, A. & Billard, A. 2003. Cuprite, paramelaconite and tenorite films deposited by reactive magnetron sputtering. Applied Surface Science 210(3-4): 359-367.

Ray, S.C. 2001. Preparation of copper oxide thin film by the sol-gel-like dip technique and study of their structural and optical properties. Solar Energy Materials and Solar Cells 68(3-4): 307-312.

Serin, N., Serin, T., Horzum, S. & Celik, Y. 2005. Annealing effects on the properties of copper oxide thin films prepared by chemical deposition. Semiconductor Science and Technology 20(5): 398-401.

Serin, T., Yildiz, A., Horzum Sahin, S. & Serin, N. 2011. Extraction of important electrical parameters of CuO. Physica B: Condensed Matter 406(3): 575-578.

Shanid, N.A.M. & Khadar, M.A. 2008. Evolution of nanostructure, phase transition and band gap tailoring in oxidized Cu thin films. Thin Solid Films 516(18): 6245-6252.

Wu, D., Zhang, Q. & Tao, M. 2006. LSDA+U study of cupric oxide: Electronic structure and native point defects. Physical Review B 73(23): 235-206.

*Pengarang untuk surat-menyurat; email: pkooi11@yahoo.com