Sains Malaysiana 43(4)(2014): 551–557

Changes on Amino Acids Content in Soybean, Garbanzo Bean and

Groundnut during Pre-treatments and Tempe Making

(Perubahan pada Kandungan Asid Amino di dalam Kacang Soya, Kacang Kuda dan Kacang

Tanah semasa Proses Pra-olahan dan Pembuatan Tempe)

AISHAH BUJANG & NURUL AKMAL TAIB*

Faculty of Applied Sciences, Universiti Teknologi MARA (UiTM), 40450 Shah Alam,

Selangor, Malaysia

Diserahkan: 14 Mac 2013/Diterima: 22 Julai 2013

ABSTRACT

Fermentation of legumes is a well-recognised preserving method that not only diversifies the sensory attributes of the legume-based foods but also enhances its nutritional value. This study aimed to evaluate the changes in amino acids content of soybean, garbanzo bean and groundnut upon pre-treatments (soaking and steaming) and fermentation times (18, 24 and 30 h). The amino acids analysis was performed with a HPLC system using AccQTag method. The results obtained showed that raw soybean contain the highest amount of essential and non-essential amino acids followed by raw garbanzo bean and groundnut. After the soaking process, the amount of amino acids obtained was significantly increased in all three legumes. However, the steaming process was found to cause significant decrease in the amino acids content. After the steaming process, the legumes were inoculated with Rhizopus oligosporus and incubated at 30^oC and 65% RH. At 18 h of fermentation time, the amount of total amino acids were found to increase by 26% in fermented groundnut and 16% in both soybean and garbanzo bean compared to after steaming. Further fermentation time of 24 h shows further enhancement in the amino acids content in all three legumes. Groundnut shows the highest increased of 71% in total amino acids content followed by 63% increased in garbanzo bean and 53% increase in soybean. However, prolong fermentation time of 30 h shows a decrease in total amino acids content in all three legumes which indicates the slow process of mould degradation have occurred. Therefore, fermented legumes must be consumed at the appropriate time of fermentation in order to get the benefit from the highest accumulation of amino acids content.

Keywords: Amino acids; fermentation; legumes; pre-treatments

ABSTRAK

FFermentasi kekacang merupakan kaedah pengawetan yang diketahui bukan sahaja dapat mempelbagaikan sifat sensori bagi makanan berasaskan kekacang tetapi juga meningkatkan nilai nutrisinya. Kajian ini bertujuan untuk menilai perubahan pada kandungan asid amino kacang soya, kacang kuda dan kacang tanah ketika pra-olahan (merendam dan mengukus) dan pada masa fermentasi (18, 24 dan 30 jam). Analisis asid amino telah dilaksanakan dengan sistem HPLC menggunakan kaedah AccQ·Tag. Keputusan yang diperoleh menunjukkan bahawa kacang soya mentah mengandungi jumlah tertinggi asid amino perlu dan tidak perlu, diikuti oleh kacang kuda mentah dan kacang tanah. Selepas proses merendam, jumlah asid amino yang diperoleh telah meningkat dengan ketara pada ketiga-tiga kekacang. Walau bagaimanapun, proses mengukus didapati telah menyebabkan penurunan ketara dalam kandungan asid amino. Selepas proses mengukus, kekacang telah diinokulasi dengan Rhizopus oligosporus dan diinkubasi pada suhu ^30oC dan kelembapan udara 65%. Pada masa fermentasi 18 jam, jumlah kandungan asid amino didapati meningkat sebanyak 26% pada kacang tanah yang telah difermentasi dan 16% dalam kedua-dua kacang soya dan kacang kuda berbanding selepas pengukusan. Fermentasi seterusnya selama 24 jam menunjukkan peningkatan dalam kandungan asid amino di dalam ketiga-tiga kekacang. Kacang tanah menunjukkan peningkatan yang tertinggi sebanyak 71% dalam jumlah kandungan asid amino diikuti dengan peningkatan 63% dalam kacang kuda dan peningkatan 53% dalam kacang soya. Walau bagaimanapun, masa fermentasi lanjut selama 30 jam menunjukkan penurunan dalam jumlah kandungan asid amino yang menunjukkan proses degradasi kulat telah berlaku. Oleh itu, kekacang yang difermentasi mestilah dimakan pada masa fermentasi yang tertentu bagi mendapat manfaat daripada pengumpulan tertinggi dalam kandungan asid amino.

Kata kunci: Asid amino; fermentasi; kekacang; proses pra-olahan

RUJUKAN

Abu-Salem, F.M. & Abou-Arab, E.A. 2011. Physico-chemical properties of tempeh produced from chickpea seeds. Journal of American Science 7(7): 107-117.

Alajaji, S.A. & El-Adawy, T.A. 2006. Nutritional composition of chickpea (Cicer arietinum L.) as affected by microwave cooking and other traditional cooking methods. Journal of Food Composition and Analysis 10: 1016-1023.

Angulo-Bejarano, P.I., Verdgo-Montoya, N.M., Cuevas- Rodriquez, E.O., Milan-Carillom, J., Mora-Escobedo, R., Lopez-Valenzuela, J.A., Garzon-Tiznado, J.A. & Reyes- Moreno, C. 2008. Tempeh flour from chickpea (Cicer arietinum L.) nutritional and physicochemical properties. Food Chemistry 105: 106-112.

Baumann, U. & Bisping, B. 1995. Proteolysis during tempe fermentation. Food Microbiology 12: 39-47.

Brennan, L., Shine, A., Hewage, C., Malthouse, J.P.G., Brindle, K.M., McClenaghan, N., Flatt, P.R. & Newsholme, P. 2002. A nuclear magnetic resonance-based demonstration of substantial oxidative L-alanine metabolism and L-alanine-enhanced glucose metabolism in a clonal pancreatic β-cell line. Diabetes Journals 81: 1714-1721.

Brumm, T.J. & Hurburgh, C.R. Jr. 2002. Quality of the 2002 Soybean Crop from the United States. Louis, MO: American Soybean Association.

Chau, C.F., Cheung, P.C. & Wong, Y.S. 1997. Effect of cooking on content of amino acids and antinutrients in three Chinese indigenous legume seeds. Journal of the Science of Food and Agriculture 75(4): 447-452.

Cuevas-Rodriguez, E.O., Verdugo-Montoya, N.M., Angulo- Bejarano, P.I., Milan-Carrillo, J., Mora-Escobedo, R., Bello- Perez, L.A., Garzon-Tiznado, J.A. & Reyes-Moreno, C. 2005. Nutritional properties of tempeh flour from quality protein maize (Zea mays L.). LWT 39(10): 1-8.

Egounlety, M. & Aworh, O.C. 2003. Effect of soaking, dehulling, cooking and fermentation with Rhizopus oligosporus on the oligosacccharides, trypsin inhibitor, phytic acid and tannins of soybean (Glycine max Merr.) cowpea (vigna unguiculata L. Walp) and groundbean (Macrotyloma geocarpa Harms). Journal of Food Engineering 56: 249-254.

Ferial, M.A.S. & Esmat, A.A.A. 2011. Physico-chemical properties of tempeh produced from chickpea seeds. Journal of American Science 7(7): 107-118.

Iqbal, A., Khalil, I.A., Ateeq, N. & Khan, S.M. 2006. Nutritional quality of important food legumes. Food Chemistry 97(2): 331-335.

Krishnan, H.B. 2005. Engineering soybean for enhanced sulfur amino acid content. Crop Science 45(2): 454-461.

Krishnan, H.B. 2000. Biochemistry and molecular biology of soybean seed storage proteins. Journal of New Seeds 2(3): 1-25.

Lisiewska, Z., Slupski, J., Kmiecik, W. & Gebczynski, P. 2008. Availability of essential and trace elements in frozen leguminous vegetables prepared for consumption according to the method of pre-freezing processing. Food Chemistry 106(2): 576-582.

McConell, G.K. 2007. Effect of L-arginine supplementation on exercise metabolism. Current Opinion in Clinical Nutrition and Metabolic Care 10: 46-51.

Nielsen, N.C., Bassuner, R. & Beaman, T. 1997. The biochemistry and cell biology of embryo storage proteins. In Cellular and Molecular Biology of Plant Seed Development, edited by Larkins, R.A. & Vasil, I.K. Dordrecht: Kliwer Academic Publishers.

Okpokwasili, G.C. & Nweke, C.O. 2005. Microbial growth and substrate utilization kinetics. African Journal of Biotechnology 5(4): 305-317.

Osman, N.M., Mohamed Ahmed, I.A. & Babiker, E.E. 2010. Fermentation and cooking of sicklepod (Cassia obtusifolia) leaves: Change in chemical and amino acid composition, antinutrients and protein fractions and digestibility. International Journal of Food Science and Technology 45(1): 124-132.

Pedrosa, M.M., Cuadroda, C., Burbano, C., Allaf, K., Haddad, J., Gelencser, E., Takacs, K., Guillamon, E. & Muzquiz, M. 2011. Effect of instant controlled pressure drop on the oligosaccharides, inositol phosphates, trypsin inhibitors and lectins contents of different legumes. Food Chemistry 10: 1016-1023.

Pisulewska, E. & Pisulewski, P.M. 2000. Trypsin inhibitor activity of legume seeds (peas, chickling vetch, lentils, and soybeans) as affected by the technique of harvest. Animal Feed Science and Technology 86: 261-265.

Sarkar, P.K., Jones, L.J., Craven, G.S., Somerset, S.M. & Palmer, C. 1997. Amino acid profiles of kinema, a soybean-fermented food. Food Chemistry 59(1): 69-75.

Seo, S.S. 2005. High performance liquid chromatographic determination of homocysteine and cystathionine in biological samples by derivatization with 6-Aminoquinolyl- N-Hydroxysuccinimidyl carbomate (AQC). Journal of the Korean Chemical Society 49(3): 278.

Siddhuraju, P. & Becker, K. 2001. Effect of various domestic processing methods on antinutrients and in vitro protein and starch digestibility of two indigenous varieties of Indian tribal pulse, Mucuna pruriens var. utilis. Journal Agriculture Food 49(6): 3058-3067.

Singh, P., Kumar, R., Sabapathy, S.N. & Bawa, A.S. 2008. Functional and edible uses of soy protein products. Comprehensive Reviews in Food Science and Food Safety 7(1): 14-28.

Slupski, J. 2010. Effect of cooking and sterilisation on the composition of amino acids in immature seeds of flageolet bean (Phaseolus vulgaris L.) cultivars. Food Chemistry 121: 1171-1176.

Song, Y.S., Frias, J., Martinez-Villaluenga, C., Vidal-Valdeverde, C. & Gonzalez de Mejia, E. 2008. Immunoreactivity reduction of soybean meal by fermentation, effect on amino acid composition and antigenicity of commercial soy products. Food Chemistry 108(2): 571-581.

Steinkraus, K.H. 2002. Fermentations in world food processing. Comprehensive Reviews in Food Science and Food Safety 1: 23-31.

Zarkadas, C.G., Voldeng, H.D., Yu, Z.R. & Choi, V. 1999. Assessment of the protein quality of nine northern adapted yellow and brown seed coated soybean cultivars by amino acid analysis. Journal Agricultural and Food Chemistry 47(12): 5009-5018.

Zarkadas, C.G., Yu, Z.R., Voldeng, H.D. & Minero-Amador, A. 1993. Assessment of the protein quality of a new high-protein soybean cultivar by amino acid analysis. Journal of Agricultural and Food Chemistry 41(12): 616-623.

*Pengarang untuk surat-menyurat; email: nurul.akmal@hotmail.com